About this replacement
Gardena String Trimmer & Hedge Cutter — 18V Li-ion Replacement Battery
This 18V 2500mAh Li-ion pack replaces the original NiMH battery in the Gardena Turbotrimmer SmallCut 300 Accu and fits the EasyCut 42 Accu hedge cutter and compatible models. The original battery shipped at 1600mAh — this cell steps up to 2500mAh at the same 18V rail. More capacity means more cuts before the next charge, without any wiring or adapter changes.
- Cross-tool compatibility — SmallCut 300 Accu, 648844, EasyCut 42 Accu: These models share the same 18V connector and BMS interface, so one pack services both the trimmer and the hedge cutter without modification.
- Bench tested on actual hardware: We ran full charge/discharge cycles — the BMS held voltage steadily under motor load and tripped cleanly at the low-voltage cutoff with no fault flags.
- First charge on a new Li-ion pack: Run a full charge before the first use. Li-ion cells arrive partially charged, and a complete initial cycle helps the BMS calibrate state-of-charge tracking accurately.
Li-ion replacing NiMH — what actually changes at the cell level
The original SmallCut 300 Accu shipped with a NiMH pack. NiMH cells discharge in a flat curve, while Li-ion holds voltage higher for longer and then drops sharply near depletion. This replacement pack includes a BMS that manages that discharge curve and protects cells from over-discharge, which NiMH packs do not require. The motor receives cleaner, more consistent voltage throughout the working session.
Trimmer won't start after swapping the battery — check the contact points first
If the trimmer doesn't respond after fitting the new pack, the most common cause is oxidation or debris on the battery contact pins inside the tool. These copper contacts corrode with outdoor exposure and break the circuit even when the battery seats firmly. Clean the contacts with a dry cloth or a cotton swab before reinserting the pack. If the unit still won't start, hold the battery in place with light pressure during startup — worn contact springs sometimes lose tension over time.