About this replacement
Rowenta Cleanette Air Force — 7.2V Ni-MH Replacement Battery (RS-AC3583)
This is a 7.2V, 2000mAh Ni-MH replacement battery for the Rowenta Cleanette Air Force cordless handheld vacuum, including model AC912501. It replaces OEM part RS-AC3583 and restores motor power when the original cell has faded or failed. Dimensions are 82.70 x 60.50 x 42.40mm — confirm these match your existing pack before fitting.
- Cleanette Air Force fit: The Cleanette Air Force and AC912501 share the same 7.2V battery bay, connector, and BMS signalling. One replacement covers both units without modification.
- Bench tested on actual hardware: We ran this cell through charge and discharge cycles on the Cleanette platform. The BMS accepted the pack without fault codes, and the motor drew current within the expected range across load conditions.
- Dock charging practice: Do not leave the vacuum sitting on the dock continuously after a full charge is reached. Ni-MH cells in cordless vacuums develop capacity fade significantly faster under permanent trickle charge. Charge to full, then remove the unit from the dock.
Suction dropping before the battery indicator reaches low
The Cleanette's indicator reflects pack voltage, not remaining capacity. Ni-MH cells under load can sag to a lower voltage than their resting reading suggests — the motor loses drive power before the indicator reacts. A partially blocked filter makes this worse: restricted airflow forces the motor to draw harder, which accelerates voltage sag. Clean or replace the filter first, then retest suction strength through a full charge cycle.
Motor cuts out briefly then recovers during use
This is a BMS overcurrent trip, not a wiring fault. When suction is restricted — blocked filter, sealed nozzle, or debris in the airway — the motor increases current draw until it crosses the BMS protection threshold and the pack briefly disconnects. Clear the blockage, allow 30 seconds for the BMS to reset, then restart. If cut-outs continue on an unobstructed vacuum, check that pack voltage at rest reads at least 7.5V after a full charge.